Ultrasonic-Assisted Alkaline Pretreatment for Enhanced Bioethanol Production from Water Hyacinth (Eichhornia crassipes) Biomass
DOI:
https://doi.org/10.53893/ijrvocas.v6i2.529Keywords:
Bioethanol, Water hyacinth, Ultrasonic-assisted pretreatment, Alkaline pretreatment, DelignificationAbstract
Water hyacinth (Eichhornia crassipes) is an abundant lignocellulosic biomass with strong potential as a feedstock for bioethanol production, but its relatively high lignin content limits the accessibility of cellulose and inhibits the subsequent hydrolysis process. This study aims to analyze the effect of ultrasonic-assisted pretreatment duration and NaOH concentration on the lignocellulosic composition and the resulting bioethanol yield from water hyacinth biomass. Pretreatment was carried out at 60°C and 60 W power with time variations of 10, 15, 20, 25, and 30 minutes and NaOH concentrations of 1 M and 2 M. The pretreated samples were analyzed for lignin, cellulose, and hemicellulose content using the Chesson method, then hydrolyzed with 3% H2SO4, fermented for 120 hours using Saccharomyces cerevisiae, distilled, and characterized. The results showed that the optimum pretreatment condition was obtained at a treatment time of 25 minutes with 2 M NaOH, which reduced the lignin content from 12.1% to 5.4%, reduced the hemicellulose content to 10.8%, increased the cellulose content from 56.0% to 75.1%, and produced the highest glucose content of 8.2%. Under these optimum conditions, the resulting bioethanol had an ethanol content of 14%, a density of 0.980 g/mL, a pH of 6.5, and a distillate volume of 42 mL. Gas chromatography-mass spectrometry analysis further confirmed ethanol as the dominant compound in the distillate, supporting the validity of the refractometric measurement. Beyond 25 minutes of pretreatment, however, the lignin content, cellulose content, and bioethanol yield all showed a slight decline, indicating that excessively prolonged ultrasonic exposure can degrade part of the biomass structure and reduce process efficiency. Overall, these results indicate that ultrasonic pretreatment combined with 2 M NaOH effectively enhances delignification and improves the potential for bioethanol production from water hyacinth biomass, although further optimization is still required to achieve a fuel-grade ethanol content.
References
[1] Kartini, A. M., & Dhokhikah, Y. (2018). Bioethanol production from sugarcane molasses with simultaneous saccharification and fermentation (SSF) method using Saccharomyces cerevisiae-Pichia stipitis consortium. IOP Conference Series: Earth and Environmental Science, 207, 012061. doi: 10.1088/1755-1315/207/1/012061
[2] Bahriawan, F., Murtono, A., & Budi, E. S. (2024). Temperature control system for the distillation process of bioethanol production from banana peel. Metrotech: Journal of Mechanical and Electrical Technology, 3(1), 16–22. doi: 10.33379/metrotech.v3i1.3567
[3] Bimestre, T. A., Júnior, J. A. M., Canettieri, E. V., & Tuna, C. E. (2022). Hydrodynamic cavitation for lignocellulosic biomass pretreatment: A review of recent developments and future perspectives. Bioresources and Bioprocessing, 9(1), 7. doi: 10.1186/s40643-022-00499-2
[4] Elwin, Lutfi, M., & Hendrawan, Y. (2014). Analysis of pretreatment time and NaOH concentration effect on cellulose, lignin and hemicellulose content of water hyacinth during pretreatment process of bioethanol. Jurnal Keteknikan Pertanian Tropis dan Biosistem, 2(2), 110–116.
[5] Farhani, I., Sawitri, I., Hariningsih, P. D., Farida, I., & Sumarna, O. (2025). Bioethanol from rice husk waste as a renewable energy source. Jurnal Engine: Energi, Manufaktur, dan Material, 9(1), 9–16. doi: 10.30588/jeemm.v9i1.2052
[6] Ferdiansyah, F., Kardiman, & Ujiburrahman. (2024). Design and analysis of a solar-powered water pump system for hydroponic farming. JETISH: Journal of Education Technology, Information, Social Sciences and Health, 3(2).
[7] Gavrila, A. I., Vartolomei, A., Calinescu, I., Vinatoru, M., Parvulescu, O. C., Psenovschi, G., Chipurici, P., & Trifan, A. (2024). Ultrasound-assisted alkaline pretreatment of biomass to enhance the extraction yield of valuable chemicals. Agronomy, 14(5), 903. doi: 10.3390/agronomy14050903
[8] Kanani, N., Banu, A., Saputro, A., Puspawati, I., & Pratama, A. (n.d.). Ultrasonic. 20–27.
[9] Kiswanto, C. M. J., & Rubianto, L. (2023). Effect of fermentation time and H2SO4 concentration on glucose content in bioethanol production from corn cobs. DISTILAT: Jurnal Teknologi Separasi, 8(4), 765–770. doi: 10.33795/distilat.v8i4.45
[10] Beluhan, S., Mihajlovski, K., Šantek, B., & Ivančić Šantek, M. (2023). The production of bioethanol from lignocellulosic biomass: Pretreatment methods, fermentation, and downstream processing. Energies, 16(19), 7003. doi: 10.3390/en16197003
[11] Permatasari, I. P., Wahyuni, D., & Rulianah, S. (2025). Bioethanol production from rice husk through hydrolysis using cellulase enzyme. DISTILAT: Jurnal Teknologi Separasi, 11(4), 670–683.
[12] Rachmawati, D. T., Sayyaf, M. F., & Suprianti, L. (2026). Delignification of cassava peel using alkaline solvent with sonication assistance. Jurnal Serambi Engineering, 11(2).
[13] Schmitz, E., Karlsson, E. N., & Adlercreutz, P. (2021). Ultrasound assisted alkaline pre-treatment efficiently solubilises hemicellulose from oat hulls. Waste and Biomass Valorization, 12(10), 5371–5381. doi: 10.1007/s12649-021-01406-0
[14] Wahyuni, S., Setyorini, D., Arruan, F., & Harsyid, M. (2025). Fermentation of water hyacinth (Eichhornia crassipes) to increase bioethanol content and cellulose yield. Jurnal Lanskap dan Lingkungan, 2(2).
[15] Simanjuntak, Y. M., & Subagyo, R. (2019). Analysis of fermentation results in bioethanol production with time variation using cassava, black glutinous rice, and white glutinous rice as raw materials. Jurnal Kinematika, 4(2), 79–90.
[16] Wulandari, P. A., Fatimura, M., & Fitriyanti, R. (2023). Effect of H2SO4 concentration and fermentation time on bioethanol production from water hyacinth (Eichhornia crassipes). Jurnal Teknologi dan Inovasi Industri, 4(2), 9–15.
[17] Ziaei-Rad, Z., Pazouki, M., Fooladi, J., Azin, M., Gummadi, S. N., & Allahverdi, A. (2023). Investigation of a robust pretreatment technique based on ultrasound-assisted, cost-effective ionic liquid for enhancing saccharification and bioethanol production from wheat straw. Scientific Reports, 13(1), 446. doi: 10.1038/s41598-022-27258-9
Additional Files
Published
How to Cite
Issue
Section
License
Copyright (c) 2026 Alya Fazza, Rizky Dwi Ramadhon, Sahrul Effendy, Yohandri Bow, Zurohaina
This work is licensed under a Creative Commons Attribution 4.0 International License.
All articles published in International Journal of Research in Vocational Studies (IJRVOCAS) are distributed under the Creative Commons Attribution 4.0 International License (CC BY 4.0).
Under this license, users are permitted to share, copy, redistribute, adapt, transform, and build upon the published work for any purpose, including commercial use, provided that appropriate credit is given to the original authors and IJRVOCAS, a link to the license is provided, and any changes made are indicated.
Authors retain the copyright of their published articles and grant IJRVOCAS the right of first publication. The journal makes published articles freely and permanently available online immediately upon publication.
Proper attribution should include the author names, article title, journal title, publication year, volume, issue, page numbers or article number where applicable, DOI or URL, and a reference to the CC BY 4.0 license.
The full terms of the Creative Commons Attribution 4.0 International License are available at:
https://creativecommons.org/licenses/by/4.0/
By submitting a manuscript to IJRVOCAS, authors agree that accepted articles will be published under the CC BY 4.0 license.
